您好,欢迎光临莱州聚峰机械有限公司官方网站!

服务热线

400-879-1999

你所在位置: 首页 >> 混凝土搅拌车资讯 > 常见问题 >
常见问题

为保证全自动混凝土搅拌车的驱动装置完好可靠应如何维护

来源:http://www.zkzdsljbc.com/ 时间:2020-11-24

  驱动装置的作用是驱动混凝土贮罐转动,它由取力器、万向轴、液压泵、液压马达、操纵阀、液压油箱及冷却装置组成。如果这部分因故障停止工作,混凝土贮罐将不能转动,这会导致车内混凝土报废,严重的甚至使整罐混凝土凝结在罐内,造成混凝土搅拌运输车报废。因此,驱动装置是否可靠是使用中需要高度重视的问题。为保证驱动装置完好可靠,应做好以下维护工作:
The driving device is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal axis, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If this part stops working due to fault, the concrete tank will not be able to rotate, which will lead to the scrapping of the concrete in the vehicle, and even make the whole tank concrete coagulate in the tank, resulting in the scrapping of the concrete mixer truck. Therefore, whether the driving device is reliable or not is a problem that needs high attention in use. In order to ensure the integrity and reliability of the drive device, the following maintenance work should be done well:
1.万向转动部分是故障多发部位,应按时加注润滑脂,并经常检查磨损情况,及时修理更换。车队应有备用的万向轴总成,以保证一旦发生故障能在几十分钟内恢复工作。
The universal rotating part is a fault prone part, so grease should be added on time, and the wear condition should be checked frequently, and the repair and replacement should be carried out in time. The team should have spare cardan shaft assembly to ensure that it can resume work in dozens of minutes in case of failure.
2.保证液压油清洁。混凝土搅拌运输车工作环境恶劣,一定要防止污水泥沙进入液压系统。液压油要按使用手册要求定期更换。一旦检查时发现液压油中混入水或泥沙,就要立即停机清洗液压系统、更换液压油。
Keep the hydraulic oil clean. The working environment of concrete mixer truck is bad, so it is necessary to prevent dirty cement sand from entering the hydraulic system. The hydraulic oil should be replaced regularly according to the requirements of the manual. Once it is found that the hydraulic oil is mixed with water or sediment, it is necessary to stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.
全自动混凝土搅拌车
3.保证液压油冷却装置有效。要定时清理液压油散热器,避免散热器被水泥堵塞,检查散热器电动风扇运转是否正常,防止液压油温度超标。液压部分只要保证液压油清洁,一般故障不多;但生产厂家不同,使用寿命则不一样。
Ensure that the hydraulic oil cooling device is effective. The hydraulic oil radiator should be cleaned regularly to prevent the radiator from being blocked by cement, and check whether the electric fan of radiator operates normally to prevent the temperature of hydraulic oil exceeding the standard. As long as the hydraulic oil is clean, there are not many faults in the hydraulic part, but the service life varies with the manufacturer.
感谢您的阅读,此文的文章来源:全自动混凝土搅拌车更多的内容和问题请点击:http://www.zkzdsljbc.com/我们会继续努力的为您提供服务,感谢您的支持!
Thank you for reading. This article is from automatic concrete mixer. For more information and questions, please click: http://www.zkzdsljbc.com/ We will continue to work hard to provide services for you, thank you for your support!


上一篇:自上料混凝土搅拌车传动油质量检测方法有哪些?
下一篇:一辆搅拌车合格的技术标准必须满足哪些?
tag:混凝土搅拌车,小型混凝土搅拌车,全自动混凝土搅拌车

为保证全自动混凝土搅拌车的驱动装置完好可靠应如何维护

作者:中科聚峰混凝土搅拌车厂家 时间:2020-11-24

  驱动装置的作用是驱动混凝土贮罐转动,它由取力器、万向轴、液压泵、液压马达、操纵阀、液压油箱及冷却装置组成。如果这部分因故障停止工作,混凝土贮罐将不能转动,这会导致车内混凝土报废,严重的甚至使整罐混凝土凝结在罐内,造成混凝土搅拌运输车报废。因此,驱动装置是否可靠是使用中需要高度重视的问题。为保证驱动装置完好可靠,应做好以下维护工作:
The driving device is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal axis, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If this part stops working due to fault, the concrete tank will not be able to rotate, which will lead to the scrapping of the concrete in the vehicle, and even make the whole tank concrete coagulate in the tank, resulting in the scrapping of the concrete mixer truck. Therefore, whether the driving device is reliable or not is a problem that needs high attention in use. In order to ensure the integrity and reliability of the drive device, the following maintenance work should be done well:
1.万向转动部分是故障多发部位,应按时加注润滑脂,并经常检查磨损情况,及时修理更换。车队应有备用的万向轴总成,以保证一旦发生故障能在几十分钟内恢复工作。
The universal rotating part is a fault prone part, so grease should be added on time, and the wear condition should be checked frequently, and the repair and replacement should be carried out in time. The team should have spare cardan shaft assembly to ensure that it can resume work in dozens of minutes in case of failure.
2.保证液压油清洁。混凝土搅拌运输车工作环境恶劣,一定要防止污水泥沙进入液压系统。液压油要按使用手册要求定期更换。一旦检查时发现液压油中混入水或泥沙,就要立即停机清洗液压系统、更换液压油。
Keep the hydraulic oil clean. The working environment of concrete mixer truck is bad, so it is necessary to prevent dirty cement sand from entering the hydraulic system. The hydraulic oil should be replaced regularly according to the requirements of the manual. Once it is found that the hydraulic oil is mixed with water or sediment, it is necessary to stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.
全自动混凝土搅拌车
3.保证液压油冷却装置有效。要定时清理液压油散热器,避免散热器被水泥堵塞,检查散热器电动风扇运转是否正常,防止液压油温度超标。液压部分只要保证液压油清洁,一般故障不多;但生产厂家不同,使用寿命则不一样。
Ensure that the hydraulic oil cooling device is effective. The hydraulic oil radiator should be cleaned regularly to prevent the radiator from being blocked by cement, and check whether the electric fan of radiator operates normally to prevent the temperature of hydraulic oil exceeding the standard. As long as the hydraulic oil is clean, there are not many faults in the hydraulic part, but the service life varies with the manufacturer.
感谢您的阅读,此文的文章来源:全自动混凝土搅拌车更多的内容和问题请点击:http://www.zkzdsljbc.com/我们会继续努力的为您提供服务,感谢您的支持!
Thank you for reading. This article is from automatic concrete mixer. For more information and questions, please click: http://www.zkzdsljbc.com/ We will continue to work hard to provide services for you, thank you for your support!


截屏,微信识别二维码

微信号:ZKJF6688

点击微信号复制,添加好友

 打开微信